«上一篇/Previous Article|本期目录/Table of Contents|下一篇/Next Article»

《建筑科学与工程学报》[ISSN:1673-2049/CN:61-1442/TU]

卷:

40卷

期数:

2023年05期

页码:

192-205

栏目:

岩土工程

出版日期:

2023-09-15

文章信息/Info

Title:

Study on vertical bearing characteristics of composite post grouting cast-in-place pile at pile bottom

文章编号:

1673-2049(2023)05-0206-10

作者:

张晓华¹,王 旭^1,2,周亚龙¹,张延杰¹,蒋代军¹

(1. 兰州交通大学 土木工程学院,甘肃 兰州 730070; 2. 兰州交通大学 道桥工程灾害防治技术国家地方联合工程实验室,甘肃 兰州 730070)

Author(s):

ZHANG Xiaohua¹, WANG Xu^1,2, ZHOU Yalong¹, ZHANG Yanjie¹, JIANG Daijun¹

(1. School of Civil Engineering, Lanzhou Jiaotong University, Lanzhou 730070, Gansu, China; 2.National and Provincial Joint Engineering Laboratory of Road & Bridge Disaster Prevention and Control, Lanzhou Jiaotong University, Lanzhou 730070, Gansu, China)

关键词:

灌注桩;  桩底后注浆;  数值模拟;  承载特性;  荷载传递;  注浆压力;  球形扩张理论

Keywords:

cast-in-place pile;  post grouting at pile bottom;  numerical simulation;  bearing characteristics;  load transfer;  grouting pressure;  spherical expansion theory

分类号:

TU473

DOI:

10.19815/j.jace.2021.11035

文献标志码:

A

摘要:

为减小沉降、固化沉渣、提高灌注桩承载力,提出一种灌注桩桩底复合式后注浆工艺,利用安装在桩底的钢板胶囊通过胶囊内外(开-闭-开式)的复合式注浆方式加固桩端周围土体。基于西凌井公路大桥工程进行灌注桩后注浆及静载试验,研究在后注浆过程中注浆压力、注浆量、桩顶位移的实时响应规律,探究桩底复合式后注浆桩的承载特性。利用ABAQUS软件对该工程桩底复合式后注浆灌注桩的承载特性进行数值模拟,并探讨注浆量及注浆体强度对承载力的影响。结果表明:桩底开-闭-开式交替注浆的3次注浆量均达到设计值,稳定时段的注浆压力平均在4.4 MPa左右,桩顶位移累计抬升1.01 mm; 复合式后注浆桩比常规桩的极限承载力提高1.9倍左右,同时在桩端以上2.5d(d为桩半径)左右的范围内,复合式后注浆桩侧摩阻力明显增大,平均侧阻达到189.7 kPa,侧阻增强系数为3.45,侧摩阻力呈“R”形分布; 随着注浆量及注浆体强度的增大,起初桩基承载力增长较快,在扩大头半径约为2.5倍的桩半径,弹性模量约为50倍的地基土弹性模量之后,承载力增长幅度较小。

Abstract:

In order to reduce settlement, solidify sediment and improve the bearing capacity of cast-in-place pile, a composite post grouting process at the pile bottom of cast-in-place pile was put out. The steel plate capsule installed at the bottom of pile was used to strengthen the soil around the pile end through the composite grouting method inside and outside the capsule(open-close-open). Based on the post grouting and static load test of cast-in-place pile in Xilingjing highway bridge project, the real-time response law of grouting pressure, grouting volume and pile top displacement in the process of post grouting was studied, and the bearing characteristics of composite post grouting pile at pile bottom were explored. The bearing characteristics of the composite post grouting cast-in-place pile at the pile bottom of the project were numerically simulated by ABAQUS software, and the effects of grouting volume and grouting strength on the bearing capacity were discussed. The results show that the three grouting volumes of open-close-open alternate grouting at pile bottom all reach the design value, the average grouting pressure in the stable period is about 4.4 MPa, and the cumulative displacement of the pile top is raised by 1.01 mm. The ultimate bearing capacity of composite post grouting pile is about 1.9 times higher than that of conventional pile. At the same time, in the range of about 2.5d(d is pile radius)above the pile end, the side friction of composite post grouting pile increases obviously, the average side resistance reaches 189.7 kPa, the side resistance enhancement coefficient is 3.45, and the side friction presents an “R” distribution. With the increase of grouting volume and grouting strength, the bearing capacity of pile foundation increases rapidly. After the diameter of pile end enlarged head is about 2.5 times of pile diameter and the elastic modulus of pile end enlarged head is about 50 times of that of foundation soil, the bearing capacity increases slightly.

参考文献/References:

[1] 曾志军,刘建华,张瑞坤,等.钻孔灌注桩桩端后注浆增强效应研究[J].中国矿业大学学报,2014,43(1):144-150.
ZENG Zhijun,LIU Jianhua,ZHANG Ruikun,et al.Research on the pile-base post-grouting enhancement effect of bored pile[J].Journal of China University of Mining & Technology,2014,43(1):144-150.
[2]王秀哲,龚维明,薛国亚,等.桩端后注浆技术的研究现状及发展[J].施工技术,2004,33(5):28-31.
WANG Xiuzhe,GONG Weiming,XUE Guoya,et al.Current research status and development of the pile-end post-grouting technology[J].Construction Technology,2004,33(5):28-31.
[3]周红波.桩侧泥皮和桩底沉渣对钻孔桩承载力影响的数值模拟[J].岩土力学,2007,28(5):956-960.
ZHOU Hongbo.Numerical simulation of effects of mud cake and bottom sediment on bearing capacity of bored pile[J].Rock and Soil Mechanics,2007,28(5):956-960.
[4]BRUCE D A.Enhancing the performance of large diameter piles by grouting[J].Ground Engineering,1986,19(4):9-15.
[5]WAN Z H,DAI G L,GONG W M.Field and theoretical analysis of response of axially loaded grouted drilled shafts in extra-thick fine sand[J].Canadian Geotechnical Journal,2020,57(3):391-407.
[6]刘金砺,祝经成.泥浆护壁灌注桩后注浆技术及其应用[J].建筑科学,1996,12(2):13-18.
LIU Jinli,ZHU Jingcheng.Technology and application of post-grouting for slurry drilling piles[J].Building Science,1996,12(2):13-18.
[7]张忠苗,吴世明,包 风.钻孔灌注桩桩底后注浆机理与应用研究[J].岩土工程学报,1999,21(6):681-686.
ZHANG Zhongmiao,WU Shiming,BAO Feng.Study of mechanism and application on bored pile end grouting[J].Chinese Journal of Geotechnical Engineering,1999,21(6):681-686.
[8]万志辉,戴国亮,王 磊,等.黏性土层中后压浆桩承载性状的对比试验研究[J].岩土工程学报,2018,40(增2):194-198.
WAN Zhihui,DAI Guoliang,WANG Lei,et al.Experimental study on bearing behaviors of post-grouting bored piles in cohesive soils[J].Chinese Journal of Geotechnical Engineering,2018,40(S2):194-198.
[9]何 剑.后注浆钻孔灌注桩承载性状试验研究[J].岩土工程学报,2002,24(6):743-746.
HE Jian.Experimental research on vertical bearing properties of base-grouting bored cast-in-place pile[J].Chinese Journal of Geotechnical Engineering,2002,24(6):743-746.
[10]吴兴序,于志强,王 旭.压力灌浆法用于灌注桩的试验研究[J].西南交通大学学报,1997,32(4):382-387.
WU Xingxu,YU Zhiqiang,WANG Xu.Application of grouting method to cast in place piles[J].Journal of Southwest Jiaotong University,1997,32(4):382-387.
[11]王 旭,吴兴序,赵善锐.黄土地区桩底压密灌浆提高灌注桩承载力的试验研究[J].西南交通大学学报,1999,34(1):16-21.
WANG Xu,WU Xingxu,ZHAO Shanrui.Experimental study on the compaction grouting of pile tip in loess region[J].Journal of Southwest Jiaotong University,1999,34(1):16-21.
[12]安爱军,李 亮,邹金锋,等.长钻孔灌注桩后注浆深度及数值模拟研究[J].铁道科学与工程学报,2011,8(2):53-58.
AN Aijun,LI Liang,ZOU Jinfeng,et al.Numerical study on depth of post-grouting in-situ of length bored pile[J].Journal of Railway Science and Engineering,2011,8(2):53-58.
[13]黄 敏,张克绪,张尔齐.桩底灌浆在桩端周围土体中引起的应力分析[J].哈尔滨工业大学学报,2002,34(3):433-435,439.
HUANG Min,ZHANG Kexu,ZHANG Erqi.Analysis of stress in soil mass around pile bottom induced by grouting[J].Journal of Harbin Institute of Technology,2002,34(3):433-435,439.
[14]康 琦,姚晓飞,徐 岳.桩端后压浆钻孔灌注桩荷载传递规律及主要影响因素分析[J].中外公路,2015,35(5):36-40.
KANG Qi,YAO Xiaofei,XU Yue.Analysis of load transfer law and main influencing factors of post-grouting bored pile at pile end[J].Journal of China & Foreign Highway,2015,35(5):36-40.
[15]胡庆立,张克绪.桩底压浆桩在轴向荷载作用下的有限元分析[J].哈尔滨建筑大学学报,2002(1):48-52.
HU Qingli,ZHANG Kexu.Analysis of base-grouted pile under axial load[J].Journal of Harbin University of Civil Engineering and Architecture,2002(1):48-52.
[16]张亚国,李镜培.考虑地表边界效应的静压沉桩挤土位移解析[J].同济大学学报(自然科学版),2018,46(9):1195-1200,1260.
ZHANG Yaguo,LI Jingpei.Analysis of ground displacement caused by pile installation considering boundary effects[J].Journal of Tongji University(Natural Science),2018,46(9):1195-1200,1260.
[17]李建军,梁仁旺.水泥土抗压强度和变形模量试验研究[J].岩土力学,2009,30(2):473-477.
LI Jianjun,LIANG Renwang.Research on compression strength and modulus of deformation of cemented soil[J].Rock and Soil Mechanics,2009,30(2):473-477.
[18]李 昉.试验分析掺砂量对水泥砂浆桩Duncan-Chang模型参数影响[J].铁道科学与工程学报,2018,15(3):645-650.
LI Fang.Experimental analysis of the influence of sand content on the Duncan-Chang model parameters of cement mortar pile[J].Journal of Railway Science and Engineering,2018,15(3):645-650.
[19]公路桥涵地基与基础设计规范:JTG 3363—2019[S].北京:人民交通出版社,2019.
Specifications for design of foundation of highway bridges and culverts:JTG 3363—2019[S].Beijing:China Communications Press,2019.
[20]刘红艳,万志辉.后压浆对超长钻孔灌注桩承载特征的影响研究[J].工业建筑,2018,48(3):91-96.
LIU Hongyan,WAN Zhihui.Research on influence of post grouting on bearing capacity characteristics of super-long bored piles[J].Industrial Construction,2018,48(3):91-96.
[21]董金荣.灌注桩侧阻力强化弱化效应研究[J].岩土工程学报,2009,31(5):658-662.
DONG Jinrong.Enhanced and weakened effect of skin friction of cast-in-situ piles[J].Chinese Journal of Geotechnical Engineering,2009,31(5):658-662.
[22]孟凡伟,蒋建平.软土地区后注浆灌注桩侧阻力分布数值研究[J].燕山大学学报,2020,44(2):173-181.
MENG Fanwei,JIANG Jianping.Numerical study on distribution of lateral frictional resistance of post-grouting bored piles in soft soil area[J].Journal of Yanshan University,2020,44(2):173-181.
[23]张常光,晏 青,吴礼舟,等.非饱和土条形地基梅耶霍夫极限承载力统一解[J].岩土工程学报,2018,40(2):252-261.
ZHANG Changguang,YAN Qing,WU Lizhou,et al.Unified solution of Meyerhof's ultimate bearing capacity for strip foundation resting on unsaturated soils[J].Chinese Journal of Geotechnical Engineering,2018,40(2):252-261.

相似文献/References:

备注/Memo

备注/Memo:

收稿日期:2021-11-19
基金项目:国家自然科学基金青年科学基金项目(51208294); 山西省交通运输厅交通建设科技项目(2021-2-01)
通信作者:王 旭(1965-),男,工学博士,教授,E-mail:publicwang@163.com。

常用功能

更新日期/Last Update: 2023-09-01