«上一篇/Previous Article|本期目录/Table of Contents|下一篇/Next Article»

《建筑科学与工程学报》[ISSN:1673-2049/CN:61-1442/TU]

卷:

40卷

期数:

2023年04期

页码:

135-143

栏目:

隧道工程

出版日期:

2023-07-10

文章信息/Info

Title:

Error analysis of equivalent thickness calculation method of tunnel thermal insulation layer in cold area

文章编号:

1673-2049(2023)04-0135-09

作者:

赵鹏宇^1,2,黄解放³,陈建勋^1,2,罗彦斌^1,2,董体健¹,荀文杰¹,刘 浏¹

(1. 长安大学 公路学院,陕西 西安 710064; 2. 长安大学 寒冷地区隧道气象与结构力学状态交通运输行业野外科学观测研究基地,陕西 西安 710064; 3. 中交一公局集团有限公司,北京 100024)

Author(s):

ZHAO Pengyu^1,2, HUANG Jiefang³, CHEN Jianxun^1,2, LUO Yanbin^1,2, DONG Tijian¹, XUN Wenjie¹, LIU Liu¹

(1. School of Highway, Chang'an University, Xi'an 710064, Shaanxi, China; 2. Scientific Observation and Research Base of Transport Industry of Meteorology and Structural Mechanical State of Tunnels in Cold Areas, Chang'an University, Xi'an 710064, Shaanxi,China; 3. CCCC First Highway Engineering Group Co.,Ltd., Beijing 100024, China)

关键词:

隧道工程;  寒冷地区;  防冻保温层;  等效厚度法;  计算误差

Keywords:

tunnel engineering;  cold area;  thermal insulation layer;  equivalent thickness method;  calculation error

分类号:

U452

DOI:

10.19815/j.jace.2022.04109

文献标志码:

A

摘要:

为分析寒冷地区隧道防冻保温层等效厚度计算方法的计算误差,考虑年周期下的隧道沿径向深度瞬态传热特性,提出了基于数值模拟计算的防冻保温层等效厚度法误差计算方法。同时采用控制变量法计算分析空气年平均温度、年温度振幅、围岩初始温度、围岩导热系数和导温系数5类因素对等效厚度法计算误差的影响。结果表明:在隧道衬砌表面铺设防冻保温层后,围岩温度影响深度减小,衬砌结构和围岩最大冻结深度出现时间较无防冻保温层铺设时,提前近20 d,说明防冻保温层铺设前后隧道结构内部传热状态存在差异,此外,衬砌结构和围岩内部为瞬态传热,因此效厚度法计算原理、假定条件与实际不符,计算结果存在误差; 等效厚度法计算结果整体偏小,但在空气年温度振幅较小或围岩初始温度较大时,计算结果存在偏大的情况; 空气年平均温度、围岩初始温度、围岩导热系数越低,空气年温度振幅、围岩导温系数越高,计算误差越大; 围岩导热系数和围岩初始温度对计算误差影响较大,当围岩导热系数为2 W?(m?K)^-1、围岩初始温度为5 ℃时,计算误差分别可达1.6 cm和1.4 cm,其余参数变化所形成的计算误差均小于1 cm。

Abstract:

In order to analyze the calculation error of the equivalent thickness calculation method for thermal insulation layer in tunnel in cold areas, the transient heat transfer characteristics of tunnel along the radial depth under annual cycles was considered. A calculation method for the error of the equivalent thickness calculation method of thermal insulation layer based on numerical simulation was proposed. Meanwhile, the control variable method was adopted to calculate and analyze the influence of the five factors, including of annual average air temperature, annual air temperature amplitude, initial temperature, thermal conductivity and thermal diffusion coefficient of rock mass, on the calculation error of the equivalent thickness method. The results show that after the thermal insulation layer is laid on the tunnel lining surface, the influence depth of surrounding rock temperature is decreased, and the maximum freezing depth of lining and surrounding rock occurs nearly 20 d earlier compared to when there is no thermal insulation layer. It indicates that there are differences in the internal heat transfer state of tunnel lining and surrounding rock before and after the thermal insulation layer laid. Additionally, the transient heat transfer occurs within the tunnel lining and surrounding rock, Therefore, the calculation principle and assumed condition of the equivalent thickness calculation method do not conform to the actual situation, resulting in an error in the calculation results. The calculation results of the equivalent thickness method are generally smaller. However, there are cases where the calculation results are larger when the annual temperature amplitude is low or the initial temperature of the surrounding rock is high. The calculation error is larger when the annual average air temperature and the initial temperature and thermal conductivity of the surrounding rock are lower. Conversely, the calculation error is larger, when the annual air temperature amplitude and thermal diffusivity of the surrounding rock are higher. The thermal conductivity and the initial temperature of the surrounding rock have a significant impact on the calculation error. When the thermal conductivity of the surrounding rock is 2 W?(m?K)^-1 and the initial temperature of the surrounding rock is 5 ℃, the calculation errors can reach 1.6 cm and 1.4 cm, respectively. The calculation errors resulting from variations in other parameters are all less than 1 cm.

参考文献/References:

[1] 赖远明,张明义,李双洋,等.寒冷地区工程理论与应用[M].北京:科学出版社,2009.
LAI Yuanming,ZHANG Mingyi,LI Shuangyang,et al.Theory and application of cold regions engineering[M].Beijing:Science Press,2009.
[2]ZHAO X,YANG X H,ZHANG H W,et al.An analytical solution for frost heave force by the multifactor of coupled heat and moisture transfer in cold-region tunnels[J].Cold Regions Science and Technology,2020,175:103077.
[3]张玉伟,谢永利,李又云,等.基于温度场时空分布特征的寒区隧道冻胀模型[J].岩土力学,2018,39(5):1625-1632.
ZHANG Yuwei,XIE Yongli,LI Youyun,et al.A frost heave model based on space-time distribution of temperature field in cold region tunnels[J].Rock and Soil Mechanics,2018,39(5):1625-1632.
[4]吴紫汪,赖远明,藏恩穆,等.寒冷地区隧道工程[M].北京:海洋出版社,2003.
WU Ziwang,LAI Yuanming,ZANG Enmu,et al.Tunnel engineering in cold area[M].Beijing:Ocean Press,2003.
[5]XIA C C,LYU Z T,LI Q,et al.Transversely isotropic frost heave of saturated rock under unidirectional freezing condition and induced frost heaving force in cold region tunnels[J].Cold Regions Science and Technology,2018,152:48-58.
[6]ZHAO X,ZHANG H W,LAI H P,et al.Temperature field characteristics and influencing factors on frost depth of a highway tunnel in a cold region[J].Cold Regions Science and Technology,2020,179:103141.
[7]ZHOU Y F,ZHANG X F,DENG J H.A mathematical optimization model of insulation layer's parameters in seasonally frozen tunnel engineering[J].Cold Regions Science and Technology,2014,101:73-80.
[8]ZHANG G Z,XIA C C,YANG Y,et al.Experimental study on the thermal performance of tunnel lining ground heat exchangers[J].Energy and Buildings,2014,77:149-157.
[9]LAI J X,WANG X L,QIU J L,et al.A state-of-the-art review of sustainable energy based freeze proof technology for cold-region tunnels in China[J].Renewable and Sustainable Energy Reviews,2018,82:3554-3569.
[10]LAI Y M,WU Z W,ZHANG S J,et al.Study of methods to control frost action in cold regions tunnels[J].Journal of Cold Regions Engineering,2003,17(4):144-152.
[11]陈建勋.公路隧道冻害防治技术[J].长安大学学报(自然科学版),2006,26(4):68-70.
CHEN Jianxun.Technique of preventing frost damage in highway tunnel[J].Journal of Chang'an University(Natural Science Edition),2006,26(4):68-70.
[12]陈建勋,张建勋,朱计华.硬质聚氨酯在寒冷地区隧道冻害防治中的应用[J].长安大学学报(自然科学版),2006,26(5):66-68.
CHEN Jianxun,ZHANG Jianxun,ZHU Jihua.Application of hard urethane foam for prevention of frost damage in tunnels at cold area[J].Journal of Chang'an University(Natural Science Edition),2006,26(5):66-68.
[13]LUO Y B,CHEN J X.Research status and progress of tunnel frost damage[J].Journal of Traffic and Transportation Engineering(English Edition),2019,6(3):297-309.
[14]万建国.我国寒区山岭交通隧道防冻技术综述与研究展望[J].隧道建设(中英文),2021,41(7):1115-1131.
WAN Jianguo.Review on and present situation and prospect of antifreezing technologies for tunnels in cold areas in China[J].Tunnel Construction,2021,41(7):1115-1131.
[15]LI S Y,NIU F J,LAI Y M,et al.Optimal design of thermal insulation layer of a tunnel in permafrost regions based on coupled heat-water simulation[J].Applied Thermal Engineering,2017,110:1264-1273.
[16]LU T S,ZHANG G Z,LIU S Y,et al.Numerical investigation of the temperature field and thermal insulation design of cold-region tunnels considering airflow effect[J].Applied Thermal Engineering,2021,191:116923.
[17]冯 强,刘炜炜,蒋斌松.玉希莫勒盖隧道温度场及保温层厚度的研究[J].现代隧道技术,2016,53(5):78-84.
FENG Qiang,LIU Weiwei,JIANG Binsong.Study on the temperature field and insulation layer thickness of the Yuximolegai tunnel[J].Modern Tunnelling Technology,2016,53(5):78-84.
[18]MA Q G,LUO X X,LAI Y M,et al.Numerical investigation on thermal insulation layer of a tunnel in seasonally frozen regions[J].Applied Thermal Engineering,2018,138:280-291.
[19]王志杰,周飞聪,周 平,等.高寒高海拔隧道保温层敷设方式及设计参数优化[J].中国公路学报,2020,33(8):182-194.
WANG Zhijie,ZHOU Feicong,ZHOU Ping,et al.Laying method and design parameter optimization of the thermal insulation layer in alpine and altitude tunnels[J].China Journal of Highway and Transport,2020,33(8):182-194.
[20]陈建勋.寒冷地区隧道防冻隔温层设计计算方法及应用[J].土木工程学报,2004,37(11):85-88.
CHEN Jianxun.Design method and application for anti-freezing thermal-protective layers in cold-area tunnels[J].China Civil Engineering Journal,2004,37(11):85-88.
[21]陈建勋,罗彦斌.寒冷地区隧道防冻隔温层厚度计算方法[J].交通运输工程学报,2007,7(2):76-79.
CHEN Jianxun,LUO Yanbin.Calculation method of antifreezing layer thickness in cold region tunnel[J].Journal of Traffic and Transportation Engineering,2007,7(2):76-79.
[22]四川省公路规划勘察设计研究院有限公司.川西高原公路隧道设计与施工技术指南[M].北京:科学出版社,2019.
Sichuan Highway Planning, Survey, Design and Research Institute Ltd.Design and construction guide for highway tunnels in Western Sichuan Plateau[M].Beijing:Science Press,2019.
[23]赵 勇.隧道设计理论与方法[M].北京:人民交通出版社,2019.
ZHAO Yong.Tunnel design theory and method[M].Beijing:China Communications Press,2019.
[24]季节性冻土地区公路设计与施工技术规范:JTG/T D31-06—2017)[S].北京:人民交通出版社,2017.
Technical specifications for design and construction of highway in seasonal frozen soil region:JTG/T D31-06—2017[S].Beijing:China Communications Press,2017.
[25]公路隧道加固技术规范:JTG/T 5440—2018[S].北京:人民交通出版社,2018.
Technical specifications for strengthening of highway tunnel:JTG/T 5440—2018[S].Beijing:China Communications Press,2018.
[26]夏才初,张国柱,肖素光.考虑衬砌和隔热层的寒区隧道温度场解析解[J].岩石力学与工程学报,2010,29(9):1767-1773.
XIA Caichu,ZHANG Guozhu,XIAO Suguang.Analytical solution to temperature fields of tunnel in cold region considering lining and insulation layer[J].Chinese Journal of Rock Mechanics and Engineering,2010,29(9):1767-1773.
[27]陈建勋,罗彦斌.寒冷地区隧道温度场的变化规律[J].交通运输工程学报,2008,8(2):44-48.
CHEN Jianxun,LUO Yanbin.Changing rules of temperature field for tunnel in cold area[J].Journal of Traffic and Transportation Engineering,2008,8(2):44-48.
[28]ZHAO P Y,CHEN J X,LUO Y B,et al.Investigation of the insulation effect of thermal insulation layer in the seasonally frozen region tunnel:a case study in the Zuomutai tunnel,China[J].Advances in Civil Engineering,2019,2019: 4978359.
[29]杨世铭,陶文铨.传热学[M].4版.北京:高等教育出版社,2006.
YANG Shiming,TAO Wenquan.Heat transfer[M].4th ed.Beijing:Higher Education Press,2006.
[30]TAKUMI K,TAKASHI M,KOUICHI F.An estimation of inner temperatures at cold region tunnel for heat insulator design[J].Journal of Structural Engineering,2008,54A:32-38.

相似文献/References:

[1]石 刚,富志鹏,谢永利,等.公路隧道穿越采空区的探测与处理技术研究[J].建筑科学与工程学报,2014,31(03):64.
　SHI Gang,FU Zhi-peng,XIE Yong-li,et al.Research on Detection and Treatment Technology of Exhausted Areas in Highway Tunnel Construction[J].Journal of Architecture and Civil Engineering,2014,31(04):64.
[2]赵 颖,赵亚哥白,郭恩栋,等.通过活断层区地铁隧道损伤分析[J].建筑科学与工程学报,2015,32(06):82.
　ZHAO Ying,ZHAO Ya-gebai,GUO En-dong,et al.Damage Analysis of Metro Tunnel Across Active Fault[J].Journal of Architecture and Civil Engineering,2015,32(04):82.
[3]孙铁军,王 伟,罗明睿,等.不同衬砌结构缺陷对隧道结构整体安全性的影响[J].建筑科学与工程学报,2017,34(03):82.
　SUN Tie-jun,WANG Wei,LUO Ming-rui,et al.Influences of Different Lining Structure Defects on Overall Safety of Tunnel Structure[J].Journal of Architecture and Civil Engineering,2017,34(04):82.
[4]朱彦鹏,何江飞,李军.黄土公路隧道浅埋段管棚注浆支护机理及监测分析[J].建筑科学与工程学报,2011,28(01):11.
　ZHU Yan-peng,HE Jiang-fei,LI Jun.Support Mechanism and Monitoring Analysis of Pipe Roof Grouting for Loess Highway Tunnel in Shallow-buried Section[J].Journal of Architecture and Civil Engineering,2011,28(04):11.
[5]陈建勋,乔雄.黄土隧道浅埋偏压洞口段套拱结构受力监测与分析[J].建筑科学与工程学报,2011,28(01):100.
　CHEN Jian-xun,QIAO Xiong.Mechanical Monitoring and Analysis of Umbrella Arch Structure in Shallow-buried Bias Loess Tunnel Entrance[J].Journal of Architecture and Civil Engineering,2011,28(04):100.
[6]王梦恕.台湾海峡越海通道方案前期研究[J].建筑科学与工程学报,2012,29(03):4.
　WANG Meng-shu.Preliminary Research on Taiwan Strait Cross-sea Channel Schemes[J].Journal of Architecture and Civil Engineering,2012,29(04):4.
[7]张立鑫,陈丽俊,陈建勋,等.单斜构造软硬互层围岩隧道变形特征及控制对策[J].建筑科学与工程学报,2021,38(06):186.[doi:10.19815/j.jace.2021.04102]
　ZHANG Li-xin,CHEN Li-jun,CHEN Jian-xun,et al.Deformation Characteristics and Treatment Measures of Tunnels in Soft and Hard Interbedded Surrounding Rock with Tilted Stratum[J].Journal of Architecture and Civil Engineering,2021,38(04):186.[doi:10.19815/j.jace.2021.04102]
[8]李大军,何鹏飞,宋克志,等.复杂硐室交叉口转向挑顶施工力学行为研究[J].建筑科学与工程学报,2023,40(02):172.[doi:10.19815/j.jace.2022.11120]
　LI Dajun,HE Pengfei,SONG Kezhi,et al.Research on construction mechanical behavior of turning overhanging at intersection of complex chamber[J].Journal of Architecture and Civil Engineering,2023,40(04):172.[doi:10.19815/j.jace.2022.11120]
[9]杨晓华,曹扬帆,肖 靖,等.开挖方式对跨基覆界面浅埋偏压隧道变形的影响分析[J].建筑科学与工程学报,2023,40(03):111.[doi:10.19815/j.jace.2021.11023]
　YANG Xiaohua,CAO Yangfan,XIAO Jing,et al.Analysis of influence of excavation methods on deformation of shallow-buried bias tunnels across base and cover interface[J].Journal of Architecture and Civil Engineering,2023,40(04):111.[doi:10.19815/j.jace.2021.11023]
[10]王永刚,尉 敏,王 江,等.涨壳式预应力中空锚杆支护效果及注浆工艺改进研究[J].建筑科学与工程学报,2023,40(03):142.[doi:10.19815/j.jace.2022.12055]
　WANG Yonggang,YU Min,WANG Jiang,et al.Study on supporting effect of expansion-shell pre-stressed hollow anchor and improvement of grouting technology[J].Journal of Architecture and Civil Engineering,2023,40(04):142.[doi:10.19815/j.jace.2022.12055]

备注/Memo

备注/Memo:

收稿日期:2022-04-21
基金项目:国家自然科学基金资助项目(U2268214,52208385); 陕西省杰出青年科学基金项目(2020JC-28); 新疆维吾尔自治区重大科技专项项目(2018A03003-4); 西藏自治区科技计划项目(XZ201801-GB-07)
作者简介:赵鹏宇(1989-),男,工学博士,讲师,E-mail:903716642@qq.com。
通信作者:陈建勋(1969-),男,工学博士,教授,博士生导师,E-mail:chenjx1969@chd.edu.cn。

常用功能

更新日期/Last Update: 2023-07-01